• Home
• Brands
• Davey Manuals
• Davey XJ Ultra
• Davey XJ Ultra Installation And Operating Instructions

Davey XJ Ultra Installation And Operating Instructions

Download Installation and operating instructions of Davey XJ Ultra Power Pump for Free or View it Online on All-Guides.com. This version of Davey XJ Ultra Manual compatible with such list of devices, as: XJ Ultra, XJ50, XJ70, XJ90, XJ90P

1

2

Installation and

Operating Instructions

for Dynajet

®

XJ Ultra/XJ70P/XJ90P

Pressure Pumps &

XJ50/XJ70/XJ90

Electric Pumps

Trouble Shooting Check List

a) MOTOR RUNS WHEN SWITCHED ON BUT DOES NOT PUMP.

 1. Suctionlineandpumpbodynotlledwithwater.

 2. Airleaksinsuctionlinesorsuctionpipenotunderwater.

 3. Airtrappedinsuctionlines(alsopossiblewithoodedsuctiondueto

unevenriseinpiping;eliminatehumpsandhollows).

 4. Nowateratsourceorwaterleveltoolow.

 5. Valveonsuctionlinesclosed.

b) PUMP SWITCHES ON AND OFF FREQUENTLY (CYCLING) -

Pressure

Pumps Only

 1. Checkthattankairpressureiscorrect-seeabove.

 2. Leakingtaps,oatvalvesetc.checkplumbing.

 3. Leakingcheckvalve/footvalve.

c) MOTOR DOESN’T START WHEN SWITCHED ON.

 1. Powernotconnected.

 2. Supplyvoltagetoolow.

 3. “Overtemperature”cut-outtripped.*

 4. Motornotfreetoturneg.ajammedimpeller.

 5. Internalmotorfault.

Maintenance

Theonlyregularattentionyournewpressuresystemrequiresistocheckthe

pressuretank’sairchargeevery6months.Thiscanbecheckedattheair

valvewithatyregauge.Donotchargetanktoahigherpressurethan168kPa

(XJUltra)or196kPa(XJ70P&XJ90P).

Tocheckairpressureintank:

1. Switchoffpump.

2. Openoutletnearesttopumptorelease

waterpressure.

3. Removeairvalvecapfromtopof

Supercelltankandchargetankto168kPa

(XJUltra)or196kPa(XJ70P&XJ90P)

usingairpumpandcheckwithtyre

gauge.

4. Switchon.

5. Closeoutlet.

After Sales Service

ForprofessionalaftersalesserviceorrepaircontactyourDaveyDealer.For

assistanceinlocatingyournearestdealercontacttheDaveyCustomerServiceCentre

on1300367866

P/N 48661-6 Supersedes P/N 48661-5

Please pass these instructions on to the operator of this equipment.

Priming and Operation

1.Fillpumpandsuctionline(on

oodedsuction,simplyopengate

valvetopump).Whenfull,t

Supercell

PressureTank

orPriming

Plugas

applicable.

2.Ensureoutletnearesttopumpis

open.

3.Ensureallvalvesinsuctionlineare

openandswitchon.

4.Primeshouldestablishalmost

immediatelyandastrongow

ofwatershouldbe

evidentfromthe

outlet.Allowwaterto

owfor10-20seconds

toexpelairthenclose

outlet.

5.AutomaticPressure

Pumpswillshutdownautomatically

withinseveralseconds.Manual

systemsmustbeswitchedoffat

thepowerpoint.

6.Ifnoowisevidentfromtap,

switchoffatpowerpointandrepeat

fromstep1ensuringthereisan

adequatesupplyofwateravailable

tothepump.

DAVEY WATER PRODUCTS GUARANTEE FOR AUSTRALIA & NEW ZEALAND

This Davey product is guaranteed to be free of material or manufacturing defects at the time of original purchase. Should any part fail

as a result of such defects within two years of original purchase, the product will be repaired free of charge.

TERMS AND CONDITIONS

1. This guarantee applies to all states and territories of Australia and New Zealand only and is subject to the provisions of the Trade

Practices Act (Aust.), the Goods and Consumer Protection Legislation of the various Australian states and the Consumers Guarantee

Act 1993 (NZ) as applicable.

2. The guarantee period commences on the date of original purchase of the equipment. Evidence of this date of original purchase

must be provided when claiming repairs under guarantee. It is recommended you retain all receipts in a safe place.

3. This guarantee covers parts and workshop labour only. Goods should be forwarded, with proof of date of original purchase, to an

Authorised Davey Service Centre freight paid.

4. This guarantee is subject to due compliance by the original purchaser with all directions and conditions set out in the Installation

and Operating Instructions. Failure to comply with these instructions, damage or breakdown caused by fair wear and tear,

negligence, misuse, incorrect installation, chemical or additives in the water, inadequate protection against freezing, rain or

other adverse weather conditions, corrosive or abrasive water, lightning or high voltage spikes or through unauthorised persons

attempting repairs are not covered under guarantee. The product must only be connected to the voltage shown on the

nameplate.

5. Without limiting the original purchaser’s entitlements under the Trade Practices Act (Aust.), the Goods & Consumer Protection

Legislation of the various Australian states, or the Consumers Guarantee Act 1993 (NZ), Davey shall not be liable for any loss of

profits or any consequential, indirect or special loss, damage or injury of any kind whatsoever arising directly or indirectly from the

product or any defect.

6. Where the Trade Practices Act (Aust.), the Goods and Consumer Protection Legislation of the various Australian states and the

Consumers Guarantee Act 1993 (NZ) does not apply, Davey shall not be liable for any loss of profits or any consequential, indirect

or special loss, damage or injury of any kind whatsoever suffered by the purchaser arising directly or indirectly from the product or

any defect and the purchaser shall indemnify Davey against any claim by any other person whatsoever in respect of any such loss,

damage or injury.

7. Nothing in this guarantee is intended to have the effect of contracting out of the provisions of the Trade Practices Act (Aust.),

the Goods and Consumer Protection Legislation of the various Australian states and Consumers Guarantee Act 1993 (NZ) except

to the extent permitted by the various Acts and this guarantee is to be modified to the extent necessary to give effect to that

intention.

8. Davey may be collecting personal information from you in order to provide you with a service. Davey Water Products Pty Ltd

promises only to use this information in accordance with the Provisions of the Privacy Act 1988 (Cth) and the Privacy Policy of

Davey Water Products Pty Ltd which is available at davey.com.au.

® Davey and Dynajet are registered trademarks of Davey Water Products Pty Ltd. © Davey Water Products Pty Ltd 2000

Never operate your Davey Dynajet

®

pump for more than a few

seconds without discharge ow.

*NOTE: For protection, the Davey pump motor is tted with an

automatic “over temperature” cut-out. Constant tripping of this

overload device indicates a problem eg. low voltage at pump,

excessive temperature (above 45

o

C) in pump enclosure.

Care should also be taken when servicing or disassembling pump to

avoid possible injury from hot pressurised water. Unplug pump,

relieve pressure by opening a tap on the discharge side of the pump

and allow any hot water in the pump to cool before attempting to

dismantle.

During servicing, use only approved, non-petrochemical based oring

and gasket lubrication. If unsure, consult your Davey Dealer for advice.

WARNING: When servicing or attending pump, always ensure power

is switched off and lead unplugged. Electrical connections should be

serviced only by qualied persons.

WARNING: Do not use hydrocarbon based or hydrocarbon propelled

sprays around the electrical components of this pump.

NOTE: Prior to installation remove the red

transport plugs from the suction and/or discharge.

Davey Water Products Pty Ltd

Member of the GUD Group

ABN

18 066 327 517

Head Office and Manufacturing

6 Lakeview Drive,

Scoresby, Australia 3179

Ph: +61 3 9730 9222

Fax: +61 3 9753 4100

Website: davey.com.au

Customer Service Centre

Ph: 1300 367 866

Fax: 1300 369 119

E-mail: sales@davey.com.au

Interstate Offices

Sydney • Brisbane • Adelaide

Perth • Townsville

International

6 Lakeview Drive,

Scoresby, Australia 3179

Ph: +61 3 9730 9222

Fax: +61 3 9753 4248

AH: +61 3 9730 9121

E-mail: export@davey.com.au

Germany

Kantstrasse 47,

04275 Leipzig

Ph: +49 341 301 0412

Fax: +49 341 301 0413

E-mail: [email protected]

New Zealand

2 Rothwell Avenue,

North Harbour, Auckland 1330

Ph: +64 9 914 3680

Fax: +64 9 914 3685

Website: daveynz.co.nz

E-mail: [email protected]

U.S.A. - Davey Pumps Inc.

1005 N. Commons Drive

Aurora, Illinois 60504

Ph: +1 630 898 6976

Fax: +1 630 851 7744

Website: daveyusa.com

E-mail: [email protected]

In accordance with AS 3350.2.41 we are obliged to inform you that this

pump is not to be used by children or inrm persons and must not be

used as a toy by children.