York CHAMPION B1HH018 Installation Instructions Manual

Download Installation instructions manual of York B1HH018 Heat Pump for Free or View it Online on All-Guides.com. This version of York B1HH018 Manual compatible with such list of devices, as: CHAMPION B1HH024, CHAMPION B1HH030, CHAMPION B1HH036, CHAMPION B1HH048, CHAMPION B1HH060

York B1HH018 Installation instructions manual - Page 1
1
York B1HH018 Installation instructions manual - Page 2
2
York B1HH018 Installation instructions manual - Page 3
3
York B1HH018 Installation instructions manual - Page 4
4
York B1HH018 Installation instructions manual - Page 5
5
York B1HH018 Installation instructions manual - Page 6
6
York B1HH018 Installation instructions manual - Page 7
7
York B1HH018 Installation instructions manual - Page 8
8
York B1HH018 Installation instructions manual - Page 9
9
York B1HH018 Installation instructions manual - Page 10
10
York B1HH018 Installation instructions manual - Page 11
11
York B1HH018 Installation instructions manual - Page 12
12
York B1HH018 Installation instructions manual - Page 13
13
York B1HH018 Installation instructions manual - Page 14
14
York B1HH018 Installation instructions manual - Page 15
15
York B1HH018 Installation instructions manual - Page 16
16
York B1HH018 Installation instructions manual - Page 17
17
York B1HH018 Installation instructions manual - Page 18
18
York B1HH018 Installation instructions manual - Page 19
19
York B1HH018 Installation instructions manual - Page 20
20
York B1HH018 Installation instructions manual - Page 21
21
York B1HH018 Installation instructions manual - Page 22
22
York B1HH018 Installation instructions manual - Page 23
23
York B1HH018 Installation instructions manual - Page 24
24
York B1HH018 Installation instructions manual - Page 25
25
York B1HH018 Installation instructions manual - Page 26
26
York B1HH018 Installation instructions manual - Page 27
27
York B1HH018 Installation instructions manual - Page 28
28
GENERAL
YORK Model B1HH units are factory assembled heat pumps
designed for outdoor installation on a roof top or a slab. Field-in-
stalled electric heater accessories are available to provide supple-
mental electric heat combined with electric cooling and heating.
The units are completely assembled on rigid, removable base
rails. All piping, refrigerant charge, and electrical wiring is
factory installed and tested. The units require only electric
power and duct connections at the point of installation.
The electric heaters have nickel-chrome resistance wire ele-
ments and utilize single point power connection.
INSPECTION
As soon as a unit is received, it should be inspected for possible
damage during transit. If damage is evident, the extent of the
damage should be noted on the carrier’s freight bill. A separate
request for inspection by the carrier’s agent should be made in
writing. Refer to Form 50.15-NM for additional information.
REFERENCE
Additional information on the design, installation, operation and
service of this equipment is available in the following reference
forms:
55.70-N1 — General Installation
55.70-N2 Pre-start & Post-start Check List
511.26-N1.1V — Electric Heater Accessory
REPLACEMENT PARTS
Refer to Replacement Parts Manual for complete listing of
replacement parts on this equipment.
All forms referenced in this instruction may be ordered from:
YORK Publications Distribution Center
Standard Register
2101 West Tecumseh Road
Norman, Oklahoma 73069
FAX (877) 379-7920
Installer should pay particular attention to the words:
NOTE, CAUTION
and
WARNING
. Notes are intended to clarify or make
the installation easier. Cautions are given to prevent equipment damage. Warnings are given to alert installer that personal injury
and/or equipment damage may result if installation procedure is not handled properly.
CAUTION
THIS PRODUCT MUST BE INSTALLED IN STRICT COMPLIANCE WITH THE ENCLOSED INSTALLATION INSTRUCTIONS
AND ANY APPLICABLE LOCAL, STATE, AND NATIONAL CODES INCLUDING, BUT NOT LIMITED TO, BUILDING, ELEC-
TRICAL, AND MECHANICAL CODES
WARNING
INCORRECT INSTALLATION MAY CREATE A CONDITION WHERE THE OPERATION OF THE PRODUCT COULD CAUSE
PERSONAL INJURY, PROPERTY DAMAGE AND/OR DEATH.
WARNING
DE-ENERGIZE THE ELECTRICAL POWER TO THE UNIT BEFORE ATTEMPTING TO INSPECT, REPAIR OR PERFORM
MAINTENANCE TO THE UNIT.
CHAMPION
®
SERIES
SINGLE PACKAGE HEAT PUMPS
Supersedes: 511.18-N2Y (498)
511.18-N2Y (799)
035-16707-000
INSTALLATION INSTRUCTION
®
MODELS B1HH018 THRU 060
1.5 THRU 5 TON
(12 SEER)